آمار
| تعداد نشریات | 26 |
| تعداد شمارهها | 447 |
| تعداد مقالات | 4,557 |
| تعداد مشاهده مقاله | 5,380,003 |
| تعداد دریافت فایل اصل مقاله | 3,580,074 |
Simulation of Mass and Heat Transfer of Orange Slice during Drying Process under Vacuum Condition Using Finite Element Method | ||
| Biomechanism and Bioenergy Research | ||
| دوره 1، شماره 2، اسفند 2022، صفحه 51-55 اصل مقاله (915.57 K) | ||
| نوع مقاله: Original Research | ||
| شناسه دیجیتال (DOI): 10.22103/bbr.2022.20484.1026 | ||
| نویسندگان | ||
| Hamed Homayounfar؛ Reza Amiri Chayjan* | ||
| Department of Biosystems Engineering, Faculty of Agriculture, Bu-Ali Sina University, Hamedan, Iran | ||
| چکیده | ||
| One of the most popular and oldest ways to preserve fruits and vegetables out of season is drying. The mass and heat transfer mechanisms during the drying of food products are complex. In this study, orange slices were dried by the natural convection with a vacuum dryer and the heat and mass transfer process of slices during drying were simulated and predicted by the finite element method using Comsol Multiphysics software. The simulation was done for temperatures of 45, 65, and 85 °C and pressure of 60 kPa. The results showed that the predicted model simulated moisture transfer (R2 between 0.92 and 0.97) and heat transfer (R2 between 0.97 and 0.99) with appropriate accuracy. The simulation showed that after the surface moisture drying, the moisture gradient was from the center to the surface, while the temperature gradient was from the surface to the center. | ||
| کلیدواژهها | ||
| Orange؛ Vacuum dryer؛ Comsol Multiphysics؛ Finite Elements؛ Simulation | ||
| مراجع | ||
|
Akar, G and Barutçu Mazı, I (2019). Color change, ascorbic acid degradation kinetics, and rehydration behavior of kiwifruit as affected by different drying methods. Journal of food process engineering, 42, e13011.
Chayjan, RA, Ghasemi, A and Sadeghi, M (2019). Stress fissuring and process duration during rough rice convective drying affected by continuous and stepwise changes in air temperature. Drying Technology, 37, 198-207.
Costa, MVD, Silva, AKND, Rodrigues, PR, Silva, LHMD and Rodrigues, AMDC (2018). Prediction of moisture transfer parameters for convective drying of shrimp at different pretreatments. Food Science and Technology, 38, 612-618.
Ghasemi, A and Chayjan, RA (2019). Numerical simulation of vitamin C degradation during dehydration process of fresh tomatoes. Journal of Food Process Engineering, 42, e13189.
Homayounfar, H, Chayjan, RA, Sarikhani, H and Kalvandi, R (2019). Thermal, physical and chemical properties of lavender leaves under near infrared vacuum, multi-stage semi-industrial continuous and open sun drying. Heat and Mass Transfer, 55, 3289-3299.
Khan, MIH, Welsh, Z, Gu, Y, Karim, M and Bhandari, B (2020). Modelling of simultaneous heat and mass transfer considering the spatial distribution of air velocity during intermittent microwave convective drying. International Journal of Heat and Mass Transfer, 153, 119668.
Lee, YH, Chin, SK and Chung, BK (2021). Drying characteristics and quality of lemon slices dried under Coulomb force-assisted heat pump drying. Drying Technology, 39, 765-776.
Majdi, H, Esfahani, JA and Mohebbi, M (2019). Optimization of convective drying by response surface methodology. Computers and electronics in Agriculture, 156, 574-584.
Nadi, F and Tzempelikos, D (2018). Vacuum drying of apples (cv. Golden Delicious): drying characteristics, thermodynamic properties, and mass transfer parameters. Heat and Mass Transfer, 54, 1853-1866.
Naji-Tabasi, S, Emadzadeh, B, Shahidi-Noghabi, M, Abbaspour, M and Akbari, E (2021). Physico‐chemical properties of powder and compressed tablets based on barberry fruit pulp. Journal of Food Measurement and Characterization, 15, 2469-2480.
Nakagawa, K, Horie, A, Nakabayashi, M, Nishimura, K and Yasunobu, T (2021). Influence of processing conditions of atmospheric freeze-drying/low-temperature drying on the drying kinetics of sliced fruits and their vitamin C retention. Journal of Agriculture and Food Research, 6, 100231.
Nosrati, M, Zare, D, Singh, CB and Stroshine, RL (2020). New approach in determination of moisture diffusivity for rough rice components in combined far-infrared drying by finite element method. Drying Technology, 38, 1721-1732.
Oskin, S, Kharchenko, S and Tsokur, D. (2021). Using comsol multiphysics in study of beebread drying modes. Engineering for Rural Development. Proceedings of the International Scientific Conference (Latvia). Latvia University of Life Sciences and Technologies.
Rajoriya, D, Shewale, SR and Hebbar, HU (2019). Refractance window drying of apple slices: Mass transfer phenomena and quality parameters. Food and Bioprocess Technology, 12, 1646-1658.
Rashidi, M, Chayjan, RA, Ghasemi, A and Ershadi, A (2021). Tomato tablet drying enhancement by intervention of infrared-A response surface strategy for experimental design and optimization. Biosystems Engineering, 208, 199-212.
Samani, BH, Gudarzi, H, Rostami, S, Lorigooini, Z, Esmaeili, Z and Jamshidi-Kia, F (2018). Development and optimization of the new ultrasonic-infrared-vacuum dryer in drying Kelussia odoratissima and its comparison with conventional methods. Industrial Crops and Products, 123, 46-54.
Thamkaew, G, Sjöholm, I and Galindo, FG (2021). A review of drying methods for improving the quality of dried herbs. Critical Reviews in Food Science and Nutrition, 61, 1763-1786.
Van Der Held, E and Van Drunen, F (1949). A method of measuring the thermal conductivity of liquids. Physica, 15, 865-881.
Wang, J, Law, C-L, Nema, PK, Zhao, J-H, Liu, Z-L, Deng, L-Z, Gao, Z-J and Xiao, H-W (2018). Pulsed vacuum drying enhances drying kinetics and quality of lemon slices. Journal of Food Engineering, 224, 129-138.
Zhong, W, Chen, X, Zhou, Y, Wu, Y and López, C (2017). Optimization of a solar aided coal-fired combined heat and power plant based on changeable integrate mode under different solar irradiance. Solar energy, 150, 437-446. | ||
|
آمار تعداد مشاهده مقاله: 189 تعداد دریافت فایل اصل مقاله: 288 |
||