آمار
| تعداد نشریات | 26 |
| تعداد شمارهها | 447 |
| تعداد مقالات | 4,557 |
| تعداد مشاهده مقاله | 5,380,003 |
| تعداد دریافت فایل اصل مقاله | 3,580,074 |
Investigating the Effects of Some Operating Parameters Affecting Biodiesel Production from Used Vegetable Oil | ||
| Biomechanism and Bioenergy Research | ||
| دوره 1، شماره 2، اسفند 2022، صفحه 65-68 اصل مقاله (536.49 K) | ||
| نوع مقاله: Original Research | ||
| شناسه دیجیتال (DOI): 10.22103/bbr.2022.20528.1029 | ||
| نویسندگان | ||
| Seyed Ahmad Ataei* ؛ Farshad Tavakoli Moghadam؛ Aram Namjo | ||
| Department of Chemical Engineering, Faculty of Engineering, Shahid Bahonar University of Kerman, Kerman, Iran | ||
| چکیده | ||
| Currently, the main source of energy used all over the world are fossil fuels. Due to their non-renewable nature as well as the environmental problems caused by their use, the need for an alternative energy source is felt. Biodiesel is a biodegradable, non-toxic and environmentally friendly substance. This substance is produced from vegetable oils and animal fats in different ways. Using the Transesterification method to produce biodiesel has advantages such as low cost, high reaction speed and better quality than other methods. In this research, the effect of factors such as temperature, stirring speed, methanol-to-oil ratio, and catalyst weight percentage on biodiesel production was investigated with the help of experimental design using Minitab software version 19. The quality of the produced product was compared with international standards by measuring some of its characteristics. The esterification reaction was carried out by methanol in the presence of sodium hydroxide catalyst. Based on the “Placket Burman” design (PBD), the influencing factors including the ratio of methanol to oil and the weight percentage of the catalyst were identified. Considering that the temperature and stirring speed do not have much effect on the process, there is no need to adjust the process temperature to reduce the production cost, and the mixing speed can be used with less energy consumption. | ||
| کلیدواژهها | ||
| Biodiesel؛ Screening, Transesterification؛ Experimental design؛ Placket Burman design | ||
| مراجع | ||
|
Athar, M, Imdad, S, Zaidi, S, Yusuf, M, Kamyab, H, Klemeš, JJ and Chelliapan, S (2022). Biodiesel production by single-step acid-catalysed transesterification of Jatropha oil under microwave heating with modelling and optimisation using response surface methodology. Fuel, 322, 124205.
Canakci, M and Van Gerpen, J (2001). Biodiesel production from oils and fats with high free fatty acids. Transactions of the ASAE, 44, 1429.
Caruana, C (1992). Pollution control drives new interest in biodiesel. Chemical engineering progress (USA).
Fangfang, F, Alagumalai, A and Mahian, O (2021). Sustainable biodiesel production from waste cooking oil: ANN modeling and environmental factor assessment. Sustainable Energy Technologies and Assessments, 46, 101265.
Ghobadian, B, Khatamifar, M and Rahimi, H (2006). Biodiesel fuel production using transesterification of waste vegetable oils. The journal of engine research, 8, 80288-7.
Hashemi, A (2014). design, construction and evaluation of a biodiesel production reactor from waste kitchen oil. master's thesis, Faculty of Agricultural Engineering, Sari University of Agricultural Sciences and Natural Resources.
Knothe, G, Krahl, J and Van Gerpen, J (2015). The biodiesel handbook, Elsevier.
Morris, R, Mansell, G, Jia, Y and Wilson, G 2003. Impact of Biodiesel Fuels on Air Quality and Human Health: Task 2 Report; The Impact of Biodiesel Fuels on Ozone Concentrations. National Renewable Energy Lab.(NREL), Golden, CO (United States).
Sigar, C, Soni, S, Mathur, J and Sharma, D (2008). Performance and emission characteristics of vegetable oil as diesel fuel extender. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 31, 139-148.
Sundar, AM and Dharmendirakumar, M (2022). Biodiesel production and comparison using commercial lipase and chemical catalyst from Cassia auriculata oil. Journal of the Indian Chemical Society, 99, 100265.
Wang, Y, Ou, S, Liu, P, Xue, F and Tang, S (2006). Comparison of two different processes to synthesize biodiesel by waste cooking oil. Journal of Molecular Catalysis A: Chemical, 252, 107-112. | ||
|
آمار تعداد مشاهده مقاله: 113 تعداد دریافت فایل اصل مقاله: 155 |
||